| 王秀东,李红浪,付琛,梁勇,何世堂.快速吸附与脱附的声表面波H2S传感器[J].,2011,30(3):213-219 |
| 快速吸附与脱附的声表面波H2S传感器 |
| Fast absorption and desorption H2S sensors based on surface acoustic waves |
| |
| 中文摘要: |
| 本文主要研究了基于SnO2/CuO薄膜的声表面波（SAW）传感器（室温下,工作频率约为147.8 MHz）检测H2S气体的特性。以36°YXLiTaO3为基片制作声表面波器件,通过采用射频磁控溅射法在其表面淀积SnO2/CuO的复合薄膜制作出H2S气体传感器。由场发射电子扫描电镜观察薄膜,薄膜连续均匀且表面分布大量微气孔,因而具有良好的吸附性。然后本文在85℃～205℃范围内对传感器的吸附和脱附速率、灵敏度及选择性等进行了实验研究。实验结果表明,所制备的传感器在较低温度下同时具备快速吸附和脱附特性,工作在190℃时气体吸附和脱附速率最快,检测20ppm H2S的响应和恢复时间分别为30s、15s;工作在160℃时,传感器检测20ppmH2S的灵敏度最高,工作频率变化约230 kHz,且对于低浓度2 ppm H2S,频率变化可达45 kHz。同时,传感器也表现出良好的重复性和选择性。 |
| 英文摘要: |
| A surface acoustic wave（SAW）sensor（operating at about 147.8 MHz at room temperature）based on SnO2/CuO composite thin films has been investigated for detecting H2S gas in this paper.The films were deposited onto a 36°YXLiTaO3 SAW device by a RF magnetron sputtering technique.From field emission electron scanning electron microscope image,it can be concluded that the films were continuous,uniform,and porous,exhibiting high absorbability.Then at different operating temperatures varying from 85℃to 205℃,the speed of adsorption and desorption,sensitivity,selectivity and other properties of sensing H2S gas were studied by experiments.Our experimental results showed that the prepared sensor possessed fast adsorption and desorption characteristics,operating at relatively low temperature. For detecting 20ppm H2S,the shortest response and recovery time of 30 s and 15 s respectively were obtained at 190℃,and the highest sensitivity of about 230kHz frequency shift was observed at 160℃.Moreover,45 kHz response can be seen for detecting low concentration of 2 ppm H2S.Satisfied repeatability and selectivity were also demonstrated by our experiments. |
| DOI：10.11684/j.issn.1000-310X.2011.03.009 |
| 中文关键词: 声表面波 SnO2/CuO H2S 气体传感器 |
| 英文关键词: SAW SnO2/CuO H2S Gas sensor |
| 基金项目:国家自然科学基金资助项目(61071054) |
|
| 摘要点击次数: 2887 |
| 全文下载次数: 895 |
|
查看全文
查看/发表评论 下载PDF阅读器 |
| 关闭 |
|
|
|
